一、产品简介 I Product Introduction FB-201 清洁剂乃是针对细线路、小孔径之高密度配线板所开发之硫酸型酸性清洁剂,使用特殊之界面活性剂,水洗性良好,具有良好之清洁力,不攻击电路板的防焊油墨及影像干膜,可强力去除铜面氧化,对铜线路表面具有清洁及活化作用。 FB-201 cleaner is a acid cleaner designed for the high-density circuit with thin line and small hole, and it uses special interface activator, has good washing ability and cleaning ability; it will not attack the solder mask and image dry film of circuit board, can remove oxide on copper surface, and has cleaning and activation function on surface of copper line.
二、配槽方法 II Makeup Method
建浴标准 : 1. Makeup Standard
1L槽液 1L solution |
主要作用 Main Function |
体积(ml) Volume |
纯水 Pure water |
溶剂 Solvent |
900ml |
FB-201 |
清洁 Cleaning |
100ml |
操作条件 : 2. Operating Condition
组份/参数 Component/Parameter |
最佳值/工作范围/要求 Optimal value/Work Scope/Requirement |
浓 度 Concentration |
10% |
温 度 Temperature |
45 ℃ (40-50 ℃) |
时 间 Time |
5 分钟(4-6 分钟) 5 minutes (4-6 minutes) |
槽 材 质 Material of bath |
使用 PVC 或 P.P 材质之槽材质 Use PVC or PP as the bath material |
加 热 器 Heater |
石英 铁氟龙 Quartz, Teflon, |
过 滤 Filter |
10-20 μm PP滤心,3-4 turn-over/hr 10-20 μm PP filter element, 3-4 turn-over/hr |
搅 拌 Mixing |
过滤循环 Filter circulation |
水 洗 Water washing |
2 段水洗 Two sections of water washing |
槽液维护 : Maintenance of solution 1) 固定添加: 1) Fixed adding 处理 1 m 2 需添加 FB-201 约 20 ml Add about 20ml FB-201 for processing 1 m 2; 2) 分析校正: 2) Analysis and calibration 依照 “ 酸性清洁剂 FB-201 分析方法 “ 分析校正 Make analysis and calibration according to “Analysis method of acid cleaner FB-201” 3) 换槽标准: 3) Bath replacing standard 2 turn-over 换槽 2 turn-over: replace bath
三、产品性状 III Product Property
品名 Product name |
外观 Appearance |
比重 Specific gravity |
PH 值 PH Value |
闪火点 Flash point |
FB-201 |
无色透明液体 Colorless transparent liquid |
1.05±0.05 |
< 1 |
不可燃 Non- combustible |
四、注意事项 IV Notes 1、酸性清洁剂 FB-201 是酸性腐蚀性液体,请避免身体直接接触,请小心使用。 1. Acid cleaner FB-201 is acid corrosive liquid, please avoid direct contact with body and use it carefully; 2、使用时请佩戴手套、安全眼镜,万一药液沾到眼睛时,请以清水冲洗 15 分锺以上,并至眼科诊所诊治。 2. When using it, Please wear gloves and eyeshade; in case of spattering into eye, immediately flush with clean water for over 15 minutes and get medical treatment; 3、产品储存请放置阴凉处,并防止日晒,以防止产品变质。 3. The product shall be stored in cool place, being away from sunshine; |